Re: P0441 Code
[Re: Fluffy]
#495291
10/12/09 02:01 PM
10/12/09 02:01 PM
|
Joined: Jan 2003
Posts: 21,084 Niles , Ohio
therocks
oh wait.but hey.lets see.oh yeah.
|
oh wait.but hey.lets see.oh yeah.
Joined: Jan 2003
Posts: 21,084
Niles , Ohio
|
Is the car running when you get gas?Thats what usually sets that code when you get gas.Sometimes a bad cap will cause it also.Rocky
Chrysler Firepower
|
|
|
Re: P0441 Code
[Re: therocks]
#495292
10/12/09 02:05 PM
10/12/09 02:05 PM
|
Joined: Sep 2005
Posts: 13,049 The Thumb O' Michigan
Fluffy
OP
Automotive STD Guy
|
OP
Automotive STD Guy
Joined: Sep 2005
Posts: 13,049
The Thumb O' Michigan
|
Quote:
Is the car running when you get gas?Thats what usually sets that code when you get gas.Sometimes a bad cap will cause it also.Rocky
Nope, never have it running. I just replaced the cap not too long ago.
|
|
|
Re: P0441 Code
[Re: Fluffy]
#495293
10/12/09 02:17 PM
10/12/09 02:17 PM
|
Joined: Jan 2003
Posts: 21,084 Niles , Ohio
therocks
oh wait.but hey.lets see.oh yeah.
|
oh wait.but hey.lets see.oh yeah.
Joined: Jan 2003
Posts: 21,084
Niles , Ohio
|
Do you fill it?Lots of people overfill.That and some pumps are too fast and the emissions setup smells it and pops the light.Rocky
Chrysler Firepower
|
|
|
Re: P0441 Code
[Re: Fluffy]
#495295
10/12/09 02:24 PM
10/12/09 02:24 PM
|
Joined: Jan 2003
Posts: 21,084 Niles , Ohio
therocks
oh wait.but hey.lets see.oh yeah.
|
oh wait.but hey.lets see.oh yeah.
Joined: Jan 2003
Posts: 21,084
Niles , Ohio
|
Next time put the gas in slow and see if it sets.Not a lot to check unless it sets all the time like everytime its cleared and resets the code withouth gassing up.Did this happen after the cap change?Rocky
Chrysler Firepower
|
|
|
Re: P0441 Code
[Re: Fluffy]
#495297
10/12/09 03:29 PM
10/12/09 03:29 PM
|
Anonymous
Unregistered
|
Anonymous
Unregistered
|
1. faulty fuel cap or... 2. a leak in the miles of tubing.
theres a procedure that uses smoke to test the line(s). expensive and time consuming. good luck.
|
|
|
Re: P0441 Code
[Re: Sub95]
#495299
10/12/09 04:45 PM
10/12/09 04:45 PM
|
Joined: Sep 2009
Posts: 186 Kansas, USA
Venomvpr900
member
|
member
Joined: Sep 2009
Posts: 186
Kansas, USA
|
POSSIBLE CAUSES -EVAP Canister -Wiring Harness Intermittent -EVAP Purge Hose (Canister to Fuel Tank) -EVAP Purge Hose (Solenoid to Canister) -EVAP Purge Solenoid Vacuum Supply -EVAP Purge Solenoid (Leaky/Stuck Open) -EVAP Purge Solenoid (Stuck Closed) Hope this helps
1987 D-100 SWB, 390hp/360ci Mopar Performance Crate, Built 998 trans, 9.25 axle with sure-grip and 3.92's - 3960#'s with driver
13.83 @ 96.36 1.98 60 ft
2003 Dodge Ram 2500 HD 5.7ltr HEMI!!!
|
|
|
Re: P0441 Code
[Re: Venomvpr900]
#495301
10/12/09 09:38 PM
10/12/09 09:38 PM
|
Joined: Sep 2005
Posts: 13,049 The Thumb O' Michigan
Fluffy
OP
Automotive STD Guy
|
OP
Automotive STD Guy
Joined: Sep 2005
Posts: 13,049
The Thumb O' Michigan
|
Quote:
POSSIBLE CAUSES
-EVAP Canister -Wiring Harness Intermittent -EVAP Purge Hose (Canister to Fuel Tank) -EVAP Purge Hose (Solenoid to Canister) -EVAP Purge Solenoid Vacuum Supply -EVAP Purge Solenoid (Leaky/Stuck Open) -EVAP Purge Solenoid (Stuck Closed)
Hope this helps
Cool, thanks.
|
|
|
Re: P0441 Code
[Re: Venomvpr900]
#495302
10/12/09 09:43 PM
10/12/09 09:43 PM
|
Joined: Dec 2003
Posts: 5,314 Carstairs, Alberta, Canada
dave571
master
|
master
Joined: Dec 2003
Posts: 5,314
Carstairs, Alberta, Canada
|
Quote:
POSSIBLE CAUSES
-EVAP Canister -Wiring Harness Intermittent -EVAP Purge Hose (Canister to Fuel Tank) -EVAP Purge Hose (Solenoid to Canister) -EVAP Purge Solenoid Vacuum Supply -EVAP Purge Solenoid (Leaky/Stuck Open) -EVAP Purge Solenoid (Stuck Closed)
Hope this helps
That code is not set by a loose gas cap or a leak in the system. (YOu would have leak codes then ie gross leak detected, small leak detected, etc..)
That code is usually set by a problem in the purge system.
If you pull off the canister and solenoid, you will likely find it is full of dirt. It may work if you clean it, but you may have to replace it all, or just some pieces.
|
|
|
|
|