Posted By: VITC_GTX
Removing windshield and rear glass from A body, how? - 11/25/08 05:56 AM
'71 Demon
Do you have to destroy the seal to remove the windshield or can it be reused (they cost $90!!)?
What about the rear window seal, can you reuse that? I am only familar with B bodies and we just cut the rear out and used the "rope" to reinstall.
Posted By: boomer
Re: Removing windshield and rear glass from A body, how? - 11/25/08 06:30 AM
How old is the seal? If it is the origional,your best bet is to cut the window out and buy new. As for removing the glass from a new seal, I have never attemped it but, I would believe it would be a difficult task for a novice to do without breaking the glass. I cut my windows out and had a professional reinstall them with new gaskets. He only charged me $120 to install both front and rear windows on my duster. Very cheap considering the cost of a new window.......
Posted By: JonsGottaDusta
Re: Removing windshield and rear glass from A body, how? - 11/25/08 06:35 AM
My dad and I have parted out a few a bodies. Our best was is to use a Razor Carpet knife to cut out the seal and carefully with one of us on the inside remove the window. Good luck.
Posted By: twister360
Re: Removing windshield and rear glass from A body, how? - 11/25/08 06:54 AM
No need to cut the seal. Take a small gauge cable and feed it from the inside of the car to the outside. Then you get someone to sit inside the car to apply a little bit of pressure against the windshield while you pull along the windshield. Should take about 10 minutes.
Posted By: 70AARcuda
Re: Removing windshield and rear glass from A body, how? - 11/25/08 07:27 AM
as far as getting installed...i needed a rear window installed in 71 dart with a new gasket.
i called several shops...everyone wanted 150 bucks and i had to bring the car to them...it is a race car..
anyway..i placed an ad on craiglist and got an offer the next day from a mobile service..
40 bucks what they charged...plus i tipped them too..
Posted By: CJK440
Re: Removing windshield and rear glass from A body, how? - 11/25/08 01:55 PM
I pulled both pieced of glass out of my 72 Duster myself and reused the gaskets after paint.
Just pull the lock strip and carefully push the glass out while using windex as a lubricant.
If its warm it will be more pliable.
Posted By: VITC_GTX
Re: Removing windshield and rear glass from A body, how? - 11/25/08 04:10 PM
My gaskets are orignal and pretty hard. I guess I will cut the windows out. I have one small chip in the windshield so I will probably need a new one. The local glass shop told me $249 installed but this does not include the gasket. I don't think $249 is bad at all for a new windshield, I was just trying to re-use the overpriced gasket.
Thanks all.